1. After the diesel generator is brought to the site, you must first choose a location. The floor should be as cemented as possible to minimize uneven spots. Next, install a muffler (smoke exhaust pipe). , here to save space, manufacturers usually do not install), air filters, etc.
2. The second step is to use a wrench to tighten all the screws above. During transportation, vibrations will occur and some screws may become loose.
3. First close the water tap, add antifreeze as much as possible, you can also add pure water or distilled water and add suitable anti-rust agents, etc. In winter, try to drain the water. in the water tank no matter south or north.
4. Add engine oil. Try adding different engine oils according to different seasons. Do not add too much which will cause a decoil surge or oil burning, which is similar to driving your own car. .
5. It is necessary to check each pipeline to see if there is a leak. This situation will practically not occur.
6. Hold the oil pump handle and squeeze the oil at a constant speed. Remember not to be too violent. Once the oil enters, you will feel pressure until it enters the oil pump.
7. Turn off the load switch first, let the diesel generator heat up first, and then start charging after meeting the operating requirements.
8. Connect the power supply to start the diesel generator. Here I recommend suitcase users that the battery wiring be firmly connected to avoid burning the battery. who have difficulty starting, Fengyue The machine uses 24V to start.
9. For the mechanical type, the speedmust be adjusted to allow the machine to reach a speed of 1500 and a pressure benefit of approximately 0.2 atmospheres. At this time, don't be too violent. should refine and observe the instrument.
10. Turn on the load. If you choose a 100kw diesel generator with two or more loads, you should start the loads individually to minimize single starts, so the machine can last longer.
11. Turn off the engine. Before turning off the engine, you should first turn off the load switch, then let the car run for about 3 minutes, then turn it off. in some areas in winter.